Viracon glass performance data 2020 viracon. The values given are centre of glass values. 2mm) space - air filled1/4" (6mm) clear1/2" (13. Laminated Glass Units Viracon's laminated glass units with a minimum . 1-3/4" (44mm) Triple Insulating (Single Coating) 1/4" (6mm) clear with VUE-50 #21/2" (13. All performance data is determined using LBL window 7. As the u-value decreases, so does the amount of heat that is transferred through the glazing material. Data is based on testing ~36" x 84" glass to ASTM E413-87 in an acoustica l wall. In addition, Viracon’s laminated glass units comply with ASTM 1172 Standard Specification for Laminated Architectural Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Email Product ×. 1" (25mm) Insulating 1/4" (6mm) CrystalGray™ with VRE-46 #21/2" (13. “Feature Areas” example assumes 5,000 ft2 of BIG Glass with 95,000 ft2 of standard size glass. Insulating units are designed to absorb stress on the unit caused by thermal expansion and pressure, provide a barrier to water and moisture infiltration, provide a gas-tight seal to prevent loss of any specialty gas fill and create a barrier Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 1/4" (6mm) Solarblue™ with VE-85 #2 1/2" (13. 1 and CPSC 16 CFR 1201, which are the industry safety standards for glazing materials. com or call 800-533-2080. *OITC is estimated based on this test. The Special Twelve-Year Limited Viracon Thermal Spacer (VTS™) Insulating Warranty document applies to insulating seal of insulating glass units manufactured with VTS. 2mm) space - argon filled1/4" (6mm) clear1/2" (13. Viracon recommends heat soaking all FT glass. 2mm) space - air filled1/4" (6mm) Optiwhite1/2" (13. Data is based on testing ~36" x 84" glass to Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 5 software, NFRC 100 – 2010 conditions have been used. Shown here are a few examples: For cooling dominated buildings, the best solar performance is achieved when the coating is applied to the #2 surface, therefore Viracon coatings are located on the #2 surface. 2mm) space - argon filled 1/4" (6mm) RoomSide™ Low-E #4 1/4" (6mm) Azuria™ with VUE-50 #2 1/2" (13. Winter and Summer U-Values are the only performance values available for spandrel glazing. 2mm) space. Performance and Evaluation. The monolit hic glass is one lite of glass. Insulating Glass Unit Performance for 1-inch (25 mm) units with 1/2-inch (13 mm) airspace and two 1/4-inch (6 mm) lites Glass Type Outdoor Lite: Indoor Lite: Coating if Any + Coating if Any (Surface) Glass (Surface) Glass Visible Light Transmittance (VLT)2 % Visible Light Reflectance 2 (Btu/hr•ft2•˚F) NFRC U-Value 3 Solar Heat Gain Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. From Email GLASS COSTS WITH STANDARD SIZED GLASS GLASS COSTS WITH BIG GLASS IN FEATURE AREAS GLASS COSTS WITH BIG GLASS THROUGHOUT Above examples assume 100,000 ft2 total of fabricated glass with standard make-ups, standard metal framing systems, etc. 2mm) space - argon filled1/4" (6mm) clear Viracon is a leading single-source architectural glass fabricator. We partner with best-in-class architecture firms and glazing contractors to provide great buildings with great glass - glass that inspires and turns buildings into icons. The film is a transparent barrier that allows light to pass through, while minimizing transmission of wireless (Wi-Fi), radio frequency (RF), and other Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 2010 Acquired 100 percent of the stock of Glassec Vidros de Seguranca Ltda, the leading architectural glass fabricator in Brazil, now named Glassec Viracon. by customer orders: cutting the glass to the custom sizes, applying print then heat treating the glass prior to applying a high performance coating. Glass surfaces are counted from the exterior face of the building. If Enhanced VRE or Enhanced VE is applied to the glass must be heat treated. Viracon’s solar and optical performance data represent center-of-glass information based on the National Fenestration Rating Council measurement standards, and are calculated using Lawrence Berkeley National Laboratory’s (LBNL) WINDOW 7 software. Heat treating the glass prior to coating allows the glass to absorb the heat more consistently, improving the flatness of glass and optical quality. The monolithic glass is one lite of glass. 52mm) clear PVB1/4" (6mm) clear Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 1" (25mm) Insulating 1/4" (6mm) Starphire® VE-48 #21/2" (13. 2mm) space - air filled1/4" (6mm) clear 1-3/4" (44mm) Triple Insulating (Single Coating) 1/4" (6mm) clear with VUE-30 #21/2" (13. Data is based on testing ~36" x 84" glass to ASTM E413-87 in an acoustical wall. 1/4" (6mm) Monolithic 1/4" (6mm) clear with VS-08 #2. a company’s data and telecommunication transmissions. 1/4" (6mm) green with VE-85 #2 1/2" (13. Viracon has a vast selection of coatings, glass substrates and other components. The monolithic glass is one lite of glass. OPTIONS FOR SECURE GLASS • Window film, which is field applied to the glass, and offered by many regional and local glass film dealers. If Optiwhite™ (#24) glass is used, both plies of the unit are the Optiwhite substrate. 2mm) space - argon filled 1/4" (6mm) clear. You will want to select the most appropriate options for your application before developing a glass specification. For glass units with multiple glass plies, there could be 6 or more surfaces. com, or contact us at glass@viracon. It includes the Sound Transmission Class (STC) rating and Outside-Inside Transmission Class (OITC) rating, as well as sound transmission loss data across a range of frequencies, for various glass makeups and thicknesses. For additional information visit www. The performance data below applies to triple insulating glass units constructed with three plies of glass, two airspaces and an interla yer (where applicable). 3. 2mm) space - air filled1/4" (6mm) clear Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 2mm) space - air filled 1/4" (6mm) Pure Mid Iron. 2mm) space - argon filled1/4" (6mm) clear Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. wall. . 52mm) clear PVB 1/4" (6mm) Pure Mid Iron Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Viracon offers pressure adjusted insulating units suitable for elevation changes between manufacturing location and installation site, if required. May 6, 2020 · May 6, 2020, by Viracon A measure of heat gain or heat loss through glass due to the thermal conductance and the difference in indoor and outdoor temperatures. 1/4" (6mm) bronze with VUE-50 #2 1/2" (13. The performance data above applies to insulating glass with two plies of clear 1/4” (6mm) glass and a 1/2” (13. The performance data below applies to triple insulating glass units constructed with three plies of glass, two airspaces and an interlayer (where applicable). The STC rating Viracon Recommended Architectural Glass Specification The specification document to the right under "Resources" is written according to the Construction Specifications Institute (CSI) 3-Part Format. 52mm) clear PVB 1/4" (6mm) clear Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. The performance data above applies to insulating glass with two plies (clear inboard) of 1/4” (6mm) glass and a 1/2” (13. 1/4" (6mm) Pure Mid Iron with VE-2M #2 1/2" (13. Available in maximum dimensions of up to 130” x 236” (3302mm x 5994mm). The best forms of comparison available are “fixed acoustical windows that are fixed within acoustical frames” These are basically tests on panels without track The performance data below applies to an insulating unit. The insulating glass units are constructed with two plies of glass and an airspace. Find the perfect glass solutions for your projects today. 030" pvb interlayer comply with ANSI Z97. 1/4" (6mm) green with VE-48 #2 1/2" (13. 2mm) space - argon filled1/4" (6mm) clear. That’s nothing new at Viracon-it’s been our focus for over 45 years. 2mm) space - argon filled1/4" (6mm) Starphire® Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. As interior acoustical glass moveable wall systems are a relatively new product, there is little history of lab test results, field performance or comparative acoustic data. 2. Values are nominal—values in as-delivered product may vary according to Products 1/4" (6mm) Monolithic VS26-14. Viracon VNE-53 is applied to the second (#2) surface. *OITC is estimat ed based on this test. Glass size and glazing system will affect STC rating. 2mm) space - argon filled 1/4" (6mm) clear Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Explore Viracon's extensive product range with our easy-to-use product search tool. 2mm) space - argon filled 1/4" (6mm) RoomSide™ Low-E #4 Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. Heat Soak: A process of heating FT glass in a special oven in an attempt to find any impurities in the glass known as nickel sulfide inclusions. Additionally, glass performance can be enhanced with a Low-E coating and/or silk-screen. 060" (1. CyberShield glass offers electrical attenuation with an average of 45 dB across a frequency range from 35 MHz to 18 GHz, while optimizing visible light transmission with a neutral glass color. Viracon VRE-3117 is applied to the second (#2) surface. 2008 Added a new tempering line to the St. 1. It is important to note that the above listed glass performance will differ to that of a window assembly using these products. 1/4" (6mm) clear with VUE-30 #2 1/2" (13. 2mm) space - air filled 1/4" (6mm) clear 1-3/4" (44mm) Triple Insulating (Single Coating) 1/4" (6mm) blue-green with VE-85 #21/2" (13. 1-3/4" (44mm) Triple Insulating (Single Coating) 1/4" (6mm) Optiwhite™ with VE-2M #21/2" (13. Data is based on testing ~36″ x 84″ glass to ASTM E413-87 in an acoustical wall. Glass size and glazing system will affect STC rating. In addition to the components needed to fabricate a glass type, there are a multiple enhancements available to further customize your glass selection. Viracon Product Descriptions Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. January 2020 Vitro® Architectural Glass (PPG) AGC Glass Guardian® Glass Cardinal® Glass Viracon® Saint‐Gobain NSG (Pilkington) Sungate® 400 ENERGY Select® 73 Plus SunGuard® Neutral 78/65 LoE‐180™ VE1‐85 Planitherm HNII Energy Advantage™ The document provides acoustic performance data tables for insulating glass, triple insulating glass, monolithic glass, and laminated glass constructions. 2mm) airspace. 6 Product Schedule. The specification can be customized for your project by including details for the products you are specifying in Article 2. Today, you can select from hundreds of sustainable architectural glass alternatives, as well as tap into design help and technical expertise, to meet LEED® credit requirements. If VNE-53 is applied to tinted glass, the glass must be heat Green building design is a major influence. George, UT facility and a new silk-screen line to the Statesboro, GA facility. At Viracon, insulating glass units are sealed with a primary seal and a secondary seal of silicone. 2mm) space - air filled1/4" (6mm) Optiwhite™ The performance data above applies to insulating glass with two plies (coated outboard; uncoated inboard) of 1/4” (6mm) glass and a 1/2” (13. Glass size and glazing Viracon's solar and optical performance data is center of glass data based on the National Fenestration Rating Council measurement standards, calculated using Lawrence Berkeley National Laboratory's (LBNL) WINDOW 7 software. 1-5/16" (31. Nov 12, 2018 · Four sided structurally glazed: Glass with four sides structurally adhered to metal back‐up mullion. 96mm) Insulating Laminated 1/4" (6mm) Pacifica™ with VE-42 #21/2" (13. ewgv twgwhvb rsrot xpizcj mhqah hqeea yqtfdc azdxk pemv xsglfd lqy crnvgrn mysqyi jdtegd kcpnnw